AEEC Home | Training Index | Index | Top | Previous | Next

ECCJ / TextReport Vietnam

Check item of factory audit
→Following items are mentioned in the audit report.
  1. General administrative matter
    • Energy management system
    • State of implementation of measurement / recording
    • State of facility and equipment maintenance
    • Management of energy consumption
    • Energy unit consumption management for major products
    • Environmental conservation related management
    • Improvement of processes
  2. Air conditioning / refrigerating facility
    • Operation management
    • Energy conservation measure
    • Operation management of cooling facilities
    • Operation management of auxiliary facilities
    • Insulation / refrigerating facilities
Energy Conservation Guidebook for Factories, 2003 Edition
  1. Pump / fan, compressor
    • Operation management of pumps / fans
    • Operation management of the pneumatic system
  2. Boiler / industrial furnace, steam system, heat exchanger, waste heat / wastewater, etc.
    • Combustion management
    • Operation / efficiency management
    • Insulation / heat insulation and prevention of heat radiation loss
    • Temperature control of exhaust gas Operation management of steam
    • Management of steam leaks / insulation
    • Optimization of piping system
    • Leveling of load
    • Recovery and reuse of steam drain
    • Operation management of heat exchanger
    • Reduction of waste heat / wastewater
  3. Substation facility, motor, lighting equipment, electrical heating facility
    • Substation facility management
    • Transformer facility management
    • Motor capacity / operation management
    • Operation management of lighting equipment
    • Operation management of electrical heating facility
  4. Improvement of processes
    • Improvement of the operation
    • Review of the factory processing line
    • Realization of efficiency improvement, continuous operation
    • Others
  5. Leveling of load, electric power contract, co-generation, new energy, etc.
    • Load leveling measure
    • Contract for control of demand and supply, etc.
    • Plan for introduction of co-generation, etc.
    • New energy, etc.
    • Energy conversion
→Detail of above listed items is on the file gProposed_items.ppth
2/16
Next
AEEC Home | Training Index | Index | Top | Previous | Next
Copyright(C) ECCJ 1996-2019